Central Technical Support Number: 1-877-OPW-TECH (877-679-8324) Calls outside US and Canada: 1-708-485-4200 Fax: 1 (800) 421-3297 Hours: Monday
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 10 of 107 2.2.2 Fuel Island Terminals The FSC3000-based fuel-managemen
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 100 of 107 4.8.8 System Testing Once the FSC3000 has been configured f
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 101 of 107 Pump Control (K800 Hybrid PCT, PCM, UPC, DPC) PCT 1 POS # 1
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 102 of 107 Pump Control (K800 Hybrid PCT, PCM, UPC, DPC) PCT 3 POS #
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 103 of 107 Pump Control (K800 Hybrid PCT, PCM, UPC, DPC) PCT 5 POS #
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 104 of 107 Pump Control (K800 Hybrid PCT, PCM, UPC, DPC PCT 7 POS #
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 105 of 107 5 System Maintenance Though the FSC3000-based card systems
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 106 of 107 5.3 Remote PCM/EPC Cabinet and Door For outside units, wipe
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 107 of 107 Index Antenna, 52, 53 Beeper, 65, 69, 72, 82 Bluetooth, 52,
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 11 of 107 2.2.3 Pump Control The FSC3000-based fuel-management system
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 12 of 107 Electronic Pump Control The FSC3000-based fuel-management sys
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 13 of 107 3 Site Installation The instructions in this section of the
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 14 of 107 3.2 Preparation of System Conduit and Wiring Requirements Al
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 15 of 107 Circuit Breakers Power to the FITs and all system hardware (F
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 16 of 107 3.3 System Installation Overview The four typical installati
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 17 of 107 3.3.2 Typical Installation Diagram of an Integrated FSC3000
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 18 of 107 3.3.3 Typical Installation Diagram of a Remote FSC3000 with
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 19 of 107 3.3.4 Typical Installation Diagram of a Remote FSC3000 with
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 2 of 107 2013 Delaware Capital Formation, Inc. All Rights Reserved. DO
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 20 of 107 3.4 FIT Installation CAUTION: Install your FIT a minimum of
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 21 of 107 Terminal Petro-Net Communication Conduit Table 3-2 FIT Commun
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 22 of 107 FIT Pedestal and Enclosure Mounting 1. Remove the access pan
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 23 of 107 3.5 PCT Installation (for K800 Hybrid Installations) CAUTiON
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 24 of 107 3.5.2 Pump/Dispenser Pulser Wiring There are two types of pu
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 25 of 107 3.6 PCM Installation The PCMs may be installed in the C/OPT,
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 26 of 107 3.6.2 Remote PCM/EPC Power, Petro-Net and HM-485 Figure 3
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 27 of 107 Remote PCM Petro-Net Communication Conduit Table 3-5 Remote
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 28 of 107 Pump Control Conduit This conduit should run from the FIT pe
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 29 of 107 3.6.4 Installing PCM(s) in a Remote Enclosure Figure 3-25 P
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 3 of 107 Table of Contents 1 Cautions! Read First. ...
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 30 of 107 PCM Board Terminal Identification Figure 3-26 PCM Maste
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 31 of 107 3.7 Universal Pump Control (UPC) Installation 3.7.1 Consol
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 32 of 107 3.7.4 EPROM Installation The personality kit contains an EPR
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 33 of 107 3.8 Direct Pump Control (DPC) Installation NOTE: For DPC Int
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 34 of 107 3.8.2 DPC Pump Control (Electronic Control) Conduit Requirem
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 35 of 107 3.8.3 Installing DPC Interface in a Remote Enclosure (for Wa
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 36 of 107 12. Connect Wayne/Gilbarco dispenser directly to the DPC int
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 37 of 107 3.8.4 Installing DPC Interface in a Terminal Pedestal (for W
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 38 of 107 Gilbarco Universal Distribution Box connected to DPC interfac
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 39 of 107 3.8.5 DPC Interface Jumper Setup (for Wayne and Gilbarco) •
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 4 of 107 3.7.2 Petro-Net Communication ...
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 40 of 107 Gilbarco Figure 3-45 DPC-Gilbarco Jumper Settings
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 41 of 107 3.8.6 Installing a Remote DPC Interface (for Gasboy®) Figu
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 42 of 107 3.8.7 Installing DPC Interface in a Terminal Pedestal (for G
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 43 of 107 3.9 Dispenser Terminal Control (DTC) Installation DTC (Dispe
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 44 of 107 3.9.2 DPC with Dispenser Terminal Control (DTC) DTC is an up
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 45 of 107 3.9.3 Installing DTC in a Remote Enclosure 1. Attach the en
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 46 of 107 Wayne CAT-specific Figure 3-54 DTC Installation for Wayne (
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 47 of 107 Gilbarco CRIND-specific 1. Direct connect to CRIND loops. F
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 48 of 107 6. Connect the brown wire from the Petro-Net terminal block
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 49 of 107 3.10 FSC3000 Installation 3.10.1 Integrated FSC3000 Communica
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 5 of 107 4.3.4 Configuration (Setup/Test Mode) ...
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 50 of 107 FSC3000 Installation in a Fuel Island Terminal K800 Hybrid 1.
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 51 of 107 3.10.2 Remote FSC3000 The remote FSC3000 must be placed in
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 52 of 107 3.10.5 FSC3000 Access Connections — MethodsDepending on the
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 53 of 107 Antenna Installation The wireless modems above require the i
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 54 of 107 3.10.7 FSC3000 Additional Connections Figure 3-65 FSC3000
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 55 of 107 DPC Interface Connection (RS-232 port 4) The FSC3000 supports
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 56 of 107 Cell Modem The cell modem connects to the gateway to provide
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 57 of 107 4 System Startup & Testing WARNING: Double-check the wi
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 58 of 107 4.2 K800 Hybrid Startup/Configuration This section describes
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 59 of 107 Switch #2 Positions 1-3: Determine the Petro-Net address for
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 6 of 107 1 Cautions! Read First. 1.1 FCC Compliance This device [the
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 60 of 107 4.2.2 Power-Up Test The K800 Hybrid terminal displays the s
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 61 of 107 4.3 C/OPT Startup/Configuration This section describes how t
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 62 of 107 4.3.2 Display Contrast To compensate for different levels
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 63 of 107 Installing the C/OPT Receipt Printer 1. Position the adapter
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 64 of 107 Clearing Paper Jams In order to clear a paper jam, detach the
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 65 of 107 4.3.4 Configuration (Setup/Test Mode) The C/OPT is configu
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 66 of 107 1. PASSWORD (Privileged) You must enter Privileged Mode to c
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 67 of 107 NOTE: A small fan can be activated to circulate air around th
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 68 of 107 NOTE: This is the current position of the door. Should door s
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 69 of 107 Press <EXIT> and then <NEXT> to move to the Print
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 7 of 107 Figure 1-3 Compressed Natural Gas (CNG) Dispensers NOTE: The
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 70 of 107 Sensors This part of the test checks the current condition of
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 71 of 107 7. PORTS (Privileged) Use this function to configure COM 1 (P
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 72 of 107 8. LIGHTS This function selects [Pocket Light OFF] or [Pocket
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 73 of 107 The "nnn" is a three-digit number. The "hhhh&
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 74 of 107 12. VALUE (Privileged) The C/OPT has 26 numbers (values) used
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 75 of 107 13. RAM This test performs a non-destructive test of the C/OP
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 76 of 107 4.4 FIT500 Startup/Configuration This section describes how
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 77 of 107 4.4.2 Receipt Printer Paper The optional receipt printer a
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 78 of 107 4.4.3 FIT500 Configuration (Setup Mode) The FIT500 is co
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 79 of 107 Display Allows one to adjust background contrast and display
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 8 of 107 2 Introduction This manual discusses the installation and con
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 80 of 107 Value The FIT500 has 26 values for special functions. Below
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 81 of 107 4.4.4 Test Mode The system will enter the test mode upon pow
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 82 of 107 Keyboard Test This test checks the operation of the keys on t
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 83 of 107 Light Test This test checks the operation of the card reader
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 84 of 107 Verify Print Config Test This test prints the system configur
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 85 of 107 4.5 PCM Startup/Configuration This section describes how to
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 86 of 107 NOTE: This setting applies to the pulsers for pump positions
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 87 of 107 Switch # 2 Positions 1-6 (Master Board) 1 2 3 4ON5 6 Address
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 88 of 107 4.5.2 PCM Testing 1. Apply power to the FIT powering the P
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 89 of 107 4.6 UPC Startup/Configuration This section describes how to
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 9 of 107 2.2 Technical Specifications Details the technical specificat
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 90 of 107 • Credit (Closed): Transactions use credit pricing. Unused (
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 91 of 107 Gilbarco UPC Status Lights Table 4-20 Gilbarco UPC Status Lig
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 92 of 107 Table 4-21 UPC DIP Switch 2, Positions 5-7 (Wayne) Switch # 2
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 93 of 107 CAUTION: Cold start the UPC when it is first powered up and
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 94 of 107 4.8 FSC3000 Configuration/Testing 4.8.1 Cold Start The FSC3
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 95 of 107 4. Connect the other end to the port label “E-NET” on the ba
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 96 of 107 4.8.5 Bluetooth®, WiFi, Cell Modem Setup When accessing the
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 97 of 107 4.8.6 USB Memory Key Operation A USB memory key can be inser
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 98 of 107 Using a USB Key with Phoenix When using Phoenix with the USB
www.opwglobal.com Doc. #: M1700, Rev. 07 Page 99 of 107 5. Open a Windows Explorer window to the USB key and select
Kommentare zu diesen Handbüchern